Little Known Facts About Concrete Roads

Concrete Roads

Brajendra Singh, New Delhi
In recent years, due to the increasing use of cement concrete as a road building material, a number of articles on 'concrete roads' have been published in NBM&CW, as well as other technical journals. Authored by experts in the field, these write-ups have comprehensively covered the various aspects of concrete roads, including their construction, and the advantages that they have over bituminous ones. However, after going through most of these articles, it has been noticed that some important facts have invariably been omitted, maybe inadvertently. This article, therefore, proposes to highlight several such little known facts about concrete roads.

The first concrete road in India was built just over a hundred years ago; in early 1914 to be precise, in the city then known as Madras (now Chennai). It was constructed outside the Municipality office, and the builder had guaranteed that it would last for at least 10 years. Unfortunately, this road did not last very long. This was not because the concrete mix was wrong, the workmanship poor, or the curing insufficient. What happened was that, in August 1914, World War I broke out, in which Britain and Germany were on opposing sides. India was then a British colony and Madras one of its most important cities. On the night of 22 September 1914, a German warship, SMS Emden, bombarded Madras with more than a hundred high explosive shells. These shells, each weighing more than 100 kgs, did considerable damage, including several petroleum tanks. Many of these shells also landed on the recently constructed concrete road, destroying most of it. Claiming force majeure, the contractor escaped paying any penalty, so nobody could be sure as to how good, or how long lasting concrete roads could be.

The same year i.e. 1914, India's first cement plant came up in Porabundar. It had a capacity of 1,000 tonnes a year. Now, of course, Indian cement plants, have individual capacities of several thousand tonnes per day.

As a result, after 1914, concrete roads came up in a fairly big way all over our country, both as urban roads and inter-city highways. The latter included the Delhi-Agra, Bombay-Poona and Mysore-Bangalore links, among others. Most of these highways, as well as large numbers of urban streets in Delhi, Bombay, Hyderabad and other cities, were built in the 1920s and 1930s. Construction of concrete roads in India, slowed down from 1940 onwards. This was because most of the cement available at that time, was being used for other higher priority works. Initially, during World War II (1939-45), the cement was reserved for the construction of a large number of factories which were needed to manufacture warlike stores (guns, small arms, ammunition, vehicles, helmets etc), as well as for building several airfields and thousands of bunkers on the Eastern Front, which was facing an invasion by the Burma-based Japanese Army.

NBM&CW September 2016

Click Here
To Know More / Contact The Manufacturer
Please provide your details we will contact you as soon as possible
Please let us know your name.
Invalid Input
Please let us know your Designation.
Invalid Input
Please let us know your City.
Please let us know your State.
Please let us know your Country.
Please let us know your Contact Number.
Please let us know your email address.
Please brief your query.

Accelerated Pavement Testing

Accelerated Pavement Testing images/Road-Pavements/40594-APTtesting.jpg The Indian road network is mainly built with flexible pavements, because of ease of construction and low initial cost as compared to concrete pavements. The flexible pavements are designed as per Indian Roads Congress Read More ...

Pavement Maintenance Management System

An efficient road transportation system is of vital importance to the economy of a nation. Road transport occupies a dominant position in the overall transportation system of India due to its advantages in terms of easy availability, flexibility Read More ...

Cement Grouted Bituminous Mix for Flexible Pavements

India has the second largest road network with heterogeneous traffic conditions. Although the road construction in India has improved a lot in the last two decades, at times, it is observed that the pavements, especially in urban areas Read More ...

Whitetopping Durable and Cost-effective Solution for City Roads

Concrete is a very durable material for the construction of roads and highways. Cement concrete has been used for the construction of new roads, highways and also for the rehabilitation of existing distressed bituminous pavements Read More ...

Utilisation of Waste Materials in Road Construction

The Road sector has been receiving a lot of attention by the central as well as state governments during the last two decades. As a result, new roads are being constructed and existing ones are being upgraded to meet the traffic demand Read More ...

Construction of Sustainable Pavements Through Recycling

Increased connectivity and improved road infrastructure developed in the country in the recent past has resulted in significant increase in the growth of traffic in terms of the number of vehicles and axle loads. However, the increased Read More ...

StrataWeb®: An Innovative Solution for Embankment Slope Protection Stabilization

Side slope erosion has always been an issue for highway embankments. Especially during the monsoons, these slopes pose a challenge. The Larsen & Toubro-IDPI SPV, constructing its 163km long Rourkela-Sambalpur toll-way road Read More ...

Role of Concrete in - Road Infrastructure

In India, the emphasis in recent years has rightly been on the housing and infrastructure, including, amongst other things, roads, power and irrigation sectors. The Global Infrastructure Outlook reflects that rising income levels Read More ...

Ammann ARS 121 Soil Compactors deployed at 354-km Purvanchal Expressway

Ammann ARS 121 Soil Compactors are bringing efficiency to an enormous, high-profile roadbuilding project in India. The compactors are handling soil work for a key section of the 354-km Purvanchal Expressway, the longest current Read More ...

Ashoka Buildcon constructs Package 4 of landmark Eastern Peripheral Expressway project

Ashoka Buildcon, which was awarded package 4 of the EPE project, constructed 22km of the 135 km EPE, at a cost of ₹789 crores. It built three grade separators, one ROB, 12 VUPs, 22 PUPs, four minor bridges and 20 Read More ...

Wirtgen: Cold milling machines have a decisive impact on quality of road rehabilitation

Wirtgen offers the widest range of cold milling machines in the industry. Customers can choose from more than 30 different types of machines, with each also available with a variety of milling widths. The lower Read More ...

Smart Pavement Materials and Emerging Technologies

Smartness describes self-adaptability, self-sensing, and multiple functionalities of the materials. These characteristics provide numerous possible applications of such materials in manufacturing and civil Read More ...

Repair of Scaled Surface Areas of Newly Constructed Cement Concrete Pavement Slabs

After 2014, the speed of the construction of cement concrete road for national highways and expressways, in cities and even at village level has significantly increased due to the policy adopted by the Government of India Read More ...

ArcelorMittal Long Products - Benefits of steel solutions in bridge design

Today's modern bridge construction projects face totally new challenges. The public, the regulators and the authorities demand structures that are cost effective during their planning, execution, lifetime and dismantling. Read More ...

From Yarn to Bridges – Strata Takes Another Giant Leap in Technical Textiles

Strata Geosystems, a global leader in the soil reinforcement industry, has opened its new state-of-the-art manufacturing facility, which will meet the growing demand for geosynthetic products in India and around the Read More ...

Bogibeel Rail-cum-Road Bridge

There are a lot of legends and prophesies floating with the current of the mighty Brahmaputra River as it tracks its course from Tibet to Bangladesh, roaring down through narrow chasms and gobbling up land in its pursuit Read More ...
NBM&CW

New Building Material & Construction World

New Building Material & Construction World
MGS Architecture

Modern Green Structures & Architecture

Modern Green Structures & Architecture
L&ST

Lifting & Specialized Transport

Lifting & Specialized Transport
II&TW

Indian Infrastructure & Tenders Week

Indian Infrastructure & Tenders Week